Carpeted Van Panels

Here s what our panels looked like as we began to attach them.

Carpeted van panels.

Jul 22 2018 we decided that rather than paneling the van walls with wood we would carpet it to get a better finish and make it seem warmer. To install the panels we used 20 countersunk machine screws and finishing washers. Remove all the hard board panels from the interior of the van. Remove all the plastic fittings and screws.

This week i take on the challenges of tracing out the panels for my walls. Hopefully this helps anyone trying to build out their van or any vehicle. All vanax lining kits are manufactured in house to order by our time served joiners and carpenters. Use heavy duty trim or automotive headliner adhesive for your vans wall panels.

It looks a lot cleaner has a nicer finish and also helps to further insulate the van and reduce condensation build up while cooking and sleeping. Protecting the inside of your van with a plywood lining protects the outside panels from dings and dents caused by loose loads which will inevitably lead to rust marks. It looks a lot cleaner has a nicer finish and also helps to further insulate the van and reduce condensation build up while cooking and sleeping. With all our panels on the van looked amazing.

If you don t want to do this on your own contact us and we can cut the wall panels for your van. Wall panels are cut from your 4x8 1 4 birch. Measure and cut the liner leave 2 inches of excess liner around the edges. The back door panel.

Carpet lining a van with removeable panels. We find that it helps to use cardboard or paper to make templates of your van wall panel areas and trim accordingly. Your van will be fully lined in one or two hours at the most. The addition of wall panels have started to tie the van conversion together there are still a lot of trim panels that will need to be built and installed to give it that clean finished look.

Spray the surface of the panel with a generous covering of glue. We used the kiravans easyliner 4 way stretch. It was still a bit strange looking because of the plastic gray panels on top but once the cabinets were in it felt like a cozy warm. Van conversion walls job well done.

We used the kiravans easyliner 4 way stretch carpet in wheat to get a nice warm but light look to the van. The full back panels.